王俊峰;李海;钟常明;唐林旺;邱廷省;刘亚奇;阮翔;刘志文;

• 1:江西理工大学资源与环境工程学院江西省矿冶环境污染控制重点实验室

摘要(Abstract)：

离子吸附型稀土矿开采过程中易产生大量低浓度稀土溶液,亟待对其有效回收处理。采用"臭氧+超声波"联合工艺处理城市剩余污泥,从剩余污泥破解后的上清液中获得提取液。通过光学显微镜和扫描电镜研究反应时间对剩余污泥絮体结构变化的影响,利用单道ICP和X荧光分析提取液成分及沉淀效果。结果表明:剩余污泥破解后,SCOD由1052 mg·L~(-1)增加至5088 mg·L~(-1),多糖和蛋白质含量分别增加215. 26,115. 55 mg·L~(-1);三维荧光检测出剩余污泥提取液含有大量类腐殖酸类物质;当反应时间为60 min时,剩余污泥形态由团状变成了颗粒状,污泥表面出现褶皱,具有空隙和层状结构,粒径减小,呈现碎片化;相对于NH_4HCO_3和草酸,提取液具有优秀的沉淀效果,稀土元素沉淀率均在89%以上;絮状沉淀物中Nd,Y,La和Ce等稀土元素占有比例相对较高,含量主要在3%～8%(质量分数)。

关键词(KeyWords)： 离子型稀土;剩余污泥;溶胞;沉淀;回收

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金项目(51674125);; 江西省科技支撑计划项目(20151BBG70016);; 江西省教育厅科技项目(GJJ160640);; 江西理工大学基金重点项目(NSFJ2014-K09)资助

作者(Author): 王俊峰;李海;钟常明;唐林旺;邱廷省;刘亚奇;阮翔;刘志文;

Email:

DOI:

参考文献(References)：

• [1]池汝安,田君.风化壳淋积型稀土矿评述[J].中国稀土学报,2007,25(6):641.Chi R A,Tian J. Review of weathered crust rare earth ore[J]. Journal of the Chinese Society of Rare Earths,2007,25(6):641.
• [2]梁长利,段敏静,许宝泉,陈陵康.稀土离子微生物吸附研究进展[J].中国稀土学报,2017,35(4):449.Liang C L,Duan M J,Xu B Q,Chen L K. Review on microbe adsorption of rare earth ions[J]. Journal of the Chinese Society of Rare Earths,2017,35(4):449.
• [3]许秋华,孙园园,周雪珍,刘艳珠,李静,李永绣.离子吸附型稀土资源绿色提取[J].中国稀土学报,2016,34(6):650.Xu Q H,Sun Y Y,Zhou X Z,Liu Y Z,Li J,Li Y X.Green extraction of ion-adsorption rare earth resources[J]. Journal of the Chinese Society of Rare Earths,2016,34(6):650.
• [4]李永绣.离子吸附型稀土资源与绿色提取[M].化学工业出版社. 2014.Li Y X. Ion Absorbing Rare Earth Resources and Green Extraction[M]. Chemical Industry Press,2014.
• [5]李永绣,许秋华,王悦,谢爱玲,侯潇,周雪珍,周新木,刘艳珠,李静,李东平.一种提高离子型稀土浸取率和尾矿安全性的方法[P].中国专利:CN103695670A,2014.Li Y X,Xu Q H,Wang Y,Xie A L,Hou X,Zhou X Z,Zhou X Z,Zhou X M,Liu Y Z,Li J,Li D P. Oneway to improve leaching rate of ion adsorption type rare earth ore and security of tailings[P]. China Patent:CN103695670A,2014.
• [6]李永绣,王悦,谢爱玲,周新木,周雪珍.从低浓度含铵稀土溶液中去除氨氮并回收稀土的方法[P].中国专利:CN103466738A,2013.Li Y X,Wang Y,Xie A L,Zhou X M,Zhou X Z.Method for removing ammonia nitrogen from rare-earth ammonium containing rare earth solution and recovering rare earth[P]. China Patent:CN103466738A,2013.
• [7]王华婷,孙昊,陈莹,王晓蓉.稀土元素在鱼体内脏中的沉淀及对肝脏中酶活性的影响[J].中国环境科学,1999,19(2):141.Wang H T,Sun H,Chen Y,Wang X R. The bioaccumulation of rare earth elements in the internalorgans of fish and their effect on the activities ofenzymes in liver[J]. China Environmental Science, 1999, 19(2):141.
• [8]朱为方,张辉,邵萍萍,冯嘉,徐素琴,伍东森,杨文教.稀土区儿童智商调查研究—Ⅰ.赣南稀土区生物效应研究[J].科学通报, 1996, 41(10):914.Zhu W F,Zhang H,Shao P P,Feng J,Xu S Q,Wu D S,Yang W J. Research on children's intelligence quotient in rare earths areas-I. Biological effects of rare earths in Southern Jiangxi Province[J]. Chinese Science Bulletin,1996,41(10):914.
• [9]李永绣,周新木,刘艳珠,李东平,李静,唐群.离子吸附型稀土高效提取和分离技术进展[J].中国稀土学报,2012,30(3):257.Li Y X,Zhou X M,Liu Y Z,Li D P,Li J,Tang Q.Development of high efficiency extraction and separation technologies of rare earths from ion-adsorbed type deposit[J]. Journal of the Chinese Society of Rare Earths,2012,30(3):257.
• [10] Keiding K,Nielsen P H. Desorption of organic macromolecules from activated sludge:effect of ionic composition[J]. Water Research,1997,31(7):1665.
• [11] Li D H. Ganczarczyk. Structrue of activated sludge flocs[J]. Biotechnol. Bioeng.,1990,35(11):57.
• [12]王红梅,吴晓萍,邱轩,刘邓.微生物成因的碳酸盐矿物研究进展[J].微生物学通报,2013,40(1):180.Wang H M,Wu X P,Qiu X,Liu D. Microbially induced carbonate precipitation:a review[J]. Microbiology China,2013,40(1):180.
• [13]国家环境保护总局.水和废水监测分析方法(第四版)[M].北京:中国环境科学出版社,1990.State Environmental Protection Administration. Water and Wastewater Monitoring and Analysis Methods(Fourth Edition)[M]. Beijing:China Environmental Science Press,1990.
• [14]蒋达和,杨明园,曹志贱.生物化学实验指导[M].武汉:武汉大学出版社,2011. 99.Jiang D H,Yang M Y,Cao Z J. Biochemical Experiment Guidance[M]. Wuhan:Wuhan University Press,2011. 99.
• [15]周修东.微波预处理剩余污泥用于微生物燃料电池产电性能研究[D].哈尔滨:哈尔滨工业大学,2011.Zhou X D. Biological Treatment and Electricity Generation from Microwave Pretreatment Sludge by Microbial Fuel Cell[D]. Harbin:Harbin Institute of Technology,2011.
• [16]姚璐璐,涂响,于会彬,徐东耀,韩璐,宋永会.三维荧光区域积分评估城市污水中溶解性有机物去除[J].环境工程学报,2013,7(2):411.Yao L L,Tu X,Yu H B,Xu D Y,Han L,Song Y H.Evaluation of dissolved organic matter removal in municipal wastewater based on fluorescence regional integration[J]. Chinese Journal of Environmental Engineering,2013,7(2):411.
• [17]高连敬,杜尔登,崔旭峰,奚军.三维荧光结合荧光区域积分法评估净水厂有机物去除效果[J].给水排水,2012,38(10):51.Gao L J,Du E D,Cui X F,Xi J. Three-dimensional fluorescence combined with fluorescence area integration method to evaluate organic matter removal efficiency in water purification plant[J]. Water&Wastewater Engineering,2012,38(10):51.
• [18]项萍,谭吉华,马永亮,段菁春,贺克斌,杨复沫,程远.大气颗粒物中类腐殖酸的研究进展[J].环境化学,2015,34(3):401.Xiang P,Tan J H,Ma Y L,Duan J C,He K B,Yang F M,Cheng Y. Research progress of humic-like substances(HULIS)in atmospheric particles[J]. Environmental Chemistry,2015,34(3):401.
• [19]贾黎,张自立.腐殖酸对La3+,Nd3+等重金属离子混合体系吸附的研究[J].中国稀土学报,2009,27(6):816.Jia L,Zhang Z L. Adsorption of La3+,Nd3+and some heavy metal Ions by Humic acid in a multi-metal-ion system[J]. Journal of the Chinese Society of Rare Earths,2009,27(6):816.
• [20]石璞玉,孙力平,谢春雨,郑亚哲,邱春生.臭氧预处理对剩余污泥特性及厌氧消化的影响[J].环境工程学报,2017,11(6):3740.Shi P Y,Sun L P,Xie C Y,Zhen Y Z,Qiu C S.Effects of ozone pretreatment on sludge characteristics and anaerobic digestion[J]. Chinese Journal of Environmental Engineering,2017,11(6):3740.
• [21]江云,朱曙光,欧阳匡中,左明明,姜宇,管冰镜,翟苏皖,王志伟,丁晨风.超声破解对剩余污泥内含营养物及粒径的影响[J].环境工程学报,2018,12(5):1303.Jiang Y,Zhu S G,Ou Yang G Z,Zuo M M,Jiang Y,Guan B J,Zhai S W,Wang Z W,Ding C F. Effect of ultrasonic cracking on nutrients and particle size of excess sludge[J]. Chinese Journal of Environmental Engineering,2018,12(5):1303.
• [22]李向蓉,张艳君,张志强.剩余污泥的资源化利用[J].环境卫生工程,2011,19(5):35.Li X R,Zhang Y J,Zhang Z Q. Reclamation of excess sludge[J]. Environmental Sanitation Engineering,2011,19(5):35.
• [23]张志强,李向蓉,张姣,夏博宇.超声法从剩余污泥中提取微生物絮凝剂的研究[J].同济大学学报(自然科学版),2013,41(2):234.Zhang Z Q,Li X R,Zhang J,Xia B Y. Microbial flocculant extraction from excess sludge by ultrasonic method[J]. Journal of Tongji University(Natural Science),2013,41(2):234.